The paper introduces the design of closed-circuit soft water cooling stave control System used in No. 3 blast furnace in Baosteel.
本文介绍了在宝钢3号高炉上采用的软水密闭循环冷却壁控制系统的设计。
The results indicate that the two factors, which are very important during operation of blast furnace and manufacturing of cooling stave, highly influence cooling capacity of cooling stave.
结果表明：这两个因素对冷却壁的性能都具有很大的影响，在高炉操作和冷却壁的设计制造中必须重视。
The mechanical properties of core in the castings such as the cooling wall of blast furnace and the rolls are enhanced by using this nodulizer.
该球化剂应用于高炉冷却壁、轧辊等铸件上，可提高其心部力学性能。
Combining with the engineering example, the transformation of frequency conversion technology of cooling water for blast furnace slag is introduced in detail.
本文通过工程改造实例，详细介绍炼铁高炉冲渣水系统变频技术改造的情况。
The effect of smelting parameters of a ferromanganese blast furnace on evaporated cooling is analyzed by mathematical statistics.
本文用数理统计的方法分析了锰铁高炉冶炼参数对汽化冷却的影响。
The lining structure with concentrated copper cooling plate-stave combined system for the large-scale blast furnace is the important guarantee of 18 ~ 20 campaign life.
大型高炉的密集式铜冷却板与冷却壁结合的炉衬结构是使高炉寿命达到18 ~20年的一项重要保证措施。
The results indicated that the three factors affected the property of the cooling stave, therefore, much importance should be attached to the designing of stave and operation of blast furnace.
结果表明，这三个因素对冷却壁的性能都具有很大的影响，在冷却壁的设计和高炉操作中必须引起重视。
The finite element mould of the cast steel cooling stave of blast furnace was established and the initial conditions and boundary conditions were determined.
建立了高炉铸钢冷却壁的有限元模型，确定了冷却壁温度场模拟的初始条件和边界条件。
The article mainly presents the technical research on the water quality stabilization treatment of high-hardness water in blast furnace circulating cooling system.
本文主要介绍了用高硬度水做高炉循环冷却水的水质稳定处理技术研究。
Using dry cooling coke may obviously improve blast furnace conditions, decrease blast furnace consumption and increase coal ejection ratio.
干熄焦可显著改善高炉炉况、降低高炉消耗、提高喷煤比。
Cooling stave is an important equipment of blast furnace and has an effect on blast furnace life directly.
冷却壁是高炉重要的冷却设备，直接影响高炉炉体的使用寿命。
The blast furnace 3, Meishan at the later phase of its campaign, with seriously eroded stack and mostly damaged cooling equipment, restrains the normal production of the blast furnace.
梅山三号高炉处于炉役后期，炉身侵蚀严重，冷却设备大量损坏，制约高炉正常生产。
Due to unsatisfactory softened water, dense water scale grows inside the cooling water jacket blast furnace.
由于软化水不合要求，使鼓风炉水套内产生了致密的水垢。
Copper cooling plate is installed in the bosh, belly and shaft of blast furnace, is an important element of metallurgical blast furnace.
高炉铜冷却板是高炉的重要冷却元件，安装在高炉炉体的炉腹、炉腰、炉身等部位。
The broken cooling plant leaked through the blast furnace, resulting in poor furnace condition and poor operation.
冷却设备破损向高炉内漏水，影响炉况及操作。
Regarding the closed-loop soft water cooling system applied in blast furnace, system configuration and respective features and purposes have been briefly described.
针对高炉软水密闭冷却系统，阐述了系统的组成及各自的特点和用途。
The properties of cores in the casts are enhanced when using this nodulizer in the key ductile iron casts, such as cooling wall of blast furnace and roller.
该球化剂应用于高炉冷却壁，轧辊等关键球铁件上可提高抗拉强度和伸长率。
Construction technology of replacing the cooling stave (S3 section) of Baosteel 's blast furnace no. 3 is introduced.
介绍宝钢三高炉s3段冷却壁更换施工技术。
During the production of modern blast furnace, factors which influence longevity of blast furnace concentrate in the cooling system of blast furnace.
现代高炉生产中，影响高炉长寿的因素越来越集中在高炉的冷却系统。
The quality condition of soft water of blast furnace cooling system in China was analysed. The corrosion test of soft water shows that the sampled soft water has medium corrosive power.
取样分析了我国高炉冷却系统软水的质量现状，通过水质腐蚀性能测试得出，取样水质均为中等腐蚀型。
The closed cooling system for the treated water provided with a air cooler can improve coo-ling effect. It becomes an important measure to increase the blast furnace campaign.
配备有空气冷却器的软水闭路循环冷却系统改善了高炉循环水的冷却状态，是延长高炉冶炼寿命的一项重要措施。
In this paper, the employed conditions of blast furnace cooling wall is simply introduced.
简要介绍了高炉冷却壁的使用工况。
The "two-step method" in-line descaling rinsing technology for the circulation cooling water system of blast furnace was presented.
介绍采用“两步法”处理高炉循环冷却水系统的在线(不停车)除垢清洗技术。
The results prove fatherly that the use of copper cooling stave has great significance to the longevity of blast furnace because of the excellent heat transfer capability of copper …
结果表明铜壁高的导热性能和钻孔工艺对高炉长寿意义重大。
Unsteady heat transfer of blast furnace cooling staves made of cast steel, spherical cast iron and copper was studied.
研究了铸钢、球墨铸铁和纯铜3种不同材质高炉冷却壁的非稳态传热过程。
Unsteady heat transfer of blast furnace cooling staves made of cast steel, spherical cast iron and copper was studied.
研究了铸钢、球墨铸铁和纯铜3种不同材质高炉冷却壁的非稳态传热过程。
应用推荐