XW型旋风除尘器也称外旋型旋风除尘器。
提出了一种新型旋风除尘器，即去除筒体，直接应用锥体的旋风除尘器。
It's introducing a new structural cyclone dust extractor that absciss cylinder and applies cone directly.
除尘设备主要包括电除尘器、布袋除尘器、旋风除尘器和湿式除尘器等。
The dedusting equipment mainly includes dust catcher, pocket dust collector, centrifugal dust separator and wet dust collector.
除尘器骨架特点壳体旋风除尘器流型设计，能起局部旋风作用，减轻滤袋负荷。
Precipitator skeleton dust cyclone flow type characteristic shell design, can remove partial whirlwind role, reduce the filter bag load.
本文分析了静电旋风除尘器的除尘机理，并介绍了静电旋风除尘器的试验结果。
This paper analyses the collecting mechanism of electrostatic cyclonic collector and introduces its experimental results.
某一旋风除尘器的分级效率曲线是在特定工况下试验求得的，不能任意推广应用。
The classification efficiency curve of a certain cyclonic is obtained by experiment under the special working conditions, so it can't be spreaded and used wilfully.
旋风除尘器是利用旋转气流产生的离心力使尘粒从气流中分离并捕集下来的装置。
The cyclone separator is one of the dust collectors, which makes use of the centrifugal force generated by rotating airflow to separate and trap the particles.
旋风除尘器内除主流外还存在着二次流现象，主要有短路流、纵向涡流、偏心环流等。
Besides the mainstream, there are still some secondary flow phenomena, such as short-circuit flow, vertical eddy and eccentric circulation vortex.
它解决了现有的旋风除尘器存在着除尘效果低、稳定性不高和过滤网不易清理的问题。
The present invention resolves the problems of the prior whirlwind dedusters, including bad dedusting effect, low stability and uneasy filter net cleaning.
根据旋风除尘器内尘气两相流的运动规律，改进旋风除尘器的结构，研制出旋风式分流除尘器。
Based on the laws of motion of biphase dust-gas flow in a cyclone, improvement was made for its design so as to develop a new-type flow-divided cyclone.
设计了一种以生石灰为粉尘的捕获剂和SO2的净化剂，以旋风除尘器与沉降室为粉尘分离设备的工艺流程。
A process was designed which used quick lime as capture reagent of the dust and SO2, cyclone separator and sedimentary chamber as separation equipment.
凝结为液态，分离和处理有一定难度。常用的净化设备有旋风除尘器、喷淋水洗塔、汽水分离器、焦油过滤。
Gas after gasification comprised the more dust, tar and water, it is must to be purified. Mainly is to.
采用旋风除尘器和滤袋除尘器，或旋风除尘器和滤芯除尘器串联的两级闭路回收系统，可达到喷粉理想回收效果。
Two stage connected closed recycle system, such as cyclone scrubber and bag filter scrubber, or cyclone and paper filter scrubber can enhance the recycle of powder.
但是旋风除尘器中存在的短路流，上灰环，二次扬尘等现象，使得固体颗粒不能被完全有效分离，降低了除尘器的分离效率。
But such as short circuit flow, up ash loop, re-entrainment exists and so on phenomenon, made the solid particle couldn't be separated efficiently, so reduced separation efficiency of the cyclone.
理论分析、半工业试验和工业应用实践的结果表明：环缝内衬旋风除尘器的除尘效率优于无环缝内衬旋风除尘器的除尘效率。
The theoretical analysis, the pilot test, as well as the industrial application have shown that the collection efficiency of this cyclone with circular crack lining is higher than of the ordinary one.
根据现场旋风除尘器的运行情况，用双目标函数加权的方法，确定了除尘器入口速度，并用PHOENICS程序对流场进行了计算和分析。
According to the operation condition, the entrance velocity of precipitator is confirmed by double object function weighting, and the fluid field is calculated by PHOENICS program.
介绍了旋风除尘器的结构和运行原理，分析了旋风除尘器中流体流动状态及除尘效果影响因素，提出了提高旋风除尘器除尘效率的改进措施。
The structure and mechanism of cyclone cleaner are introduced, and cyclone cleaner fluid running state and dust impact factors of removal efficiency are analyzed.
通过对多管旋风除尘器内气流阻力平衡分析，探讨多管旋风除尘器中各旋风子单体的气流分配状况，建立了气流分布计算模型，结合算例进行了分析。
An investigation on dusted airflow distribution in gas chamber of multicyclone has been carried out by using the principle that the resistance of dusted airflow in it would keep equilibrium.
为了避免固体很快损失，旋风分离器和电器除尘器应当有很高的捕集效率。
To avoid rapid loss of solids, cyclones and electrostatic precipitators should have a very high collecting efficiency.
其装置由风机、可燃气体源、燃烧器、加料器、喷动床、旋风分离器、静电除尘器、冷凝器及流量计、温度计、控制装置等组成。
Its equipment is formed from fan, flammable gas source, combustor, feeder, spouted bed, cyclone separator, static dust-remover, condensator, flowmeter, thermometer and control device.
本文主要介绍一种适用于中密度纤维板生产的新型旋风分离器的应用效果和构造特点，并与带惯性除尘器的下旋型旋风分离器作了制造成本上的比较。
The paper introduces the practical results and structure features of a new type cyclone suited for MDF production line, and also carries on the cost comparing the new cyclone with dow cyclone.
干粉产品由旋风分离器收集，尾气经布袋除尘器除尘后排空。
The exhaust air goes into the cyclone to recover the entrained dust, then discharges after the bag filter.
在结构上它既具有旋风式重滤除尘器的特征，又具有滤网式过滤除尘的特征，还设有清扫除尘器的除尘喷嘴和吹灰喷嘴。
In this structure, both it is whirlwind filtering duster and strainer filtering dust. The dusting nozzle of cleaning duster and ash blowing nozzle are mounted into the separator.
本旋风式滤筒除尘器稳定性较高、使用寿命长、操作简单、实用性较高。
The whirlwind type filter cartridge deduster has the advantages of high stability, long service life, simple operation and high practicability.
对扁平式气流粉碎机、主要附属设备贮气罐、配气罐、旋风分离器进行了设计，并对压缩机、袋式除尘器进行了选型。
We design the flat jet mill by gas stream and the major appurtenance of disintegrator set such as air holder, distribution tank and cyclone separator, and select the compressor and bag filter.
该除尘器装有文氏管、旋风体、湿帽、泡沫除尘室、挡水栅、供水系统和引风装置。
The wet type dust-removing apparatus comprises a venturi tube, a cyclone body, a wet cap, a foam dedusting chamber, a water blocking gate, a water supply system and an inducing draught device.
一个沉降室可以组配多个旋风收尘器和颗粒层除尘器。
One settling chamber can be assembled with a plurality of cyclonic dust removers and granule layer dust removers.
探讨如何进行高温烟气除尘器的设计，并介绍了高温多管陶瓷旋风烟气除尘器的结构。
To discuss How to design the High Temperature Cyclone Dust Catcher, and introduce the constitute of the High Temperature Many-Pipe Crockery Cyclone Dust Catcher.
探讨如何进行高温烟气除尘器的设计，并介绍了高温多管陶瓷旋风烟气除尘器的结构。
To discuss How to design the High Temperature Cyclone Dust Catcher, and introduce the constitute of the High Temperature Many-Pipe Crockery Cyclone Dust Catcher.
应用推荐